Weight Weenies

Still no answer form Lightweight...

I think they too busy with Eurobike... Bad timming!!!

I am in California and had a relatively new LBS mechanic damage a rear wheel spoke about 6 months after I got my new Lightweight wheels in 2008. He shifted the chain off the big cog into the spokes (almost immediately after I told him he would need to set the stop so be very careful) and one spoke was only attached by fibers although the wheel was still true. (It is doubtful it would have survived shipping anywhere). The LBS contacted Craig Calfee in Santa Cruz, drove it to his shop and he repaired it perfectly. Got it back in about a week. You would not know that it was repaired unless I showed you where. I don't know what he charged. The shop picked up the cost. Craig still does carbon fibre repair (in addition to still making his own frames), although I am sure it is generally just frames.

Visit starbike.com Online Retailer for HighEnd cycling components
Great Prices ✓    Broad Selection ✓    Worldwide Delivery ✓

www.starbike.com

4 months and 736km... 200€ later...

Same spoke... The repair didn't hold...

Lightweight gives a 1 year warranty for the repair...
But I don't know what to do.

Asked price to repair in other place... 490 to 590€...

Repaired once again by Lightweight CarbonSports... Looks very good

On the way...

What did they charge for the second repair?

Have I missed something, paying once again for the same repair?

kgt wrote: ↑

Sat Feb 22, 2020 7:47 am

What did they charge for the second repair?

No I didn't pay anything more... The repair as 1 year guarantee

Looks like I have a similar issue due to pure stupidity on my end...

Wonder if it held also wonder how you damaged yours. I tried to wheelie and laded the spoke on a pole....

Lightweight should be able to put a rim with broken spokes into the original manufacturing mould/jig and get the pre load tension just right before fixing a crack in a spoke.

Any other repair shop will have difficulties getting the spoke pre load correct which might result in an wheel that is not straight.

Mine is holding great... since the last repair from Lighweight... no complains...

I don’t know how it was damaged... was cleaning the bike and normally check the spokes for surprises and notice a small crack...